Material Safety Data Sheet

DRAKEOL MINERAL OIL HEAVY VISCOSITY

MATERIAL SAFETY DATA SHEET

__________________________________________________________________________

# 1. PRODUCT AND COMPANY IDENTIFICATION

DRAKEOL(R) MINERAL OIL - 34

MSDS Number: PEN13388 Version Date: 07/26/06

Product Name: DRAKEOL(R) MINERAL OIL -

Synonyms: DRAKEOL(R) 19, 21, 25, 32, 34, 34A, 35, 350, 400

Manufacturer

Penreco

138 Petrolia Street

Karns City, PA 16041-9799

USA

Phone Numbers

Medical Emergency: 1-800-342-5119 or 1-281-493-2767

Transport Emergency

INFOTRAC (800)535-5053

MSDS Assistance: 1-281-293-5550

Internet Address: www.conoco.com

___________________________________________________________________________

2. COMPONENT INFORMATION

Hazardous

COMPONENT CAS No. Wt. % in Blend

White Mineral Oil 8042-47-5 100 No

___________________________________________________________________________

3. HAZARDS IDENTIFICATION

EMERGENCY OVERVIEW

APPEARANCE / ODOR

Transparent water-white liquid / Odorless.

OSHA REGULATORY STATUS

This material is NOT HAZARDOUS according to the OSHA Hazard Communication

Standard, 29CFR 1910.1200.

HMIS RATINGS: Health 0; Flammability 1; Reactivity 0.

NFPA RATINGS: Health 0; Flammability 1; Instability 0.

__________________

HEALTH EFFECT INFORMATION

PRIMARY ROUTE OF EXPOSURE: Skin.

EYE CONTACT:

This product is minimally irritating to the eyes upon direct contact.

Based on testing of similar products and/or components.

SKIN CONTACT:

This product is not expected to cause any skin irritation upon direct

single or repeated and prolonged contact; however, similar chemical

composition products applied to the skin of laboratory animals resulted in

minimal to slight dermal irritation.

INHALATION:

This product has a low vapor pressure and is not expected to present an

inhalation hazard at ambient conditions. Caution should be taken to

prevent aerosolization or misting of this product. See Section 8 for oil

mist exposure limits.

INGESTION:

This product is relatively non-toxic by ingestion unless aspiration occurs.

This product has laxative properties and may result in abdominal cramps and

diarrhea.

OTHER:

Exposure to a large single dose, or repeated smaller doses of mineral oil

by inhalation, aspiration or ingestion leading to aspiration can lead to

lipid pneumonia or lipid granuloma. These are low-grade, chronic,

localized tissue reactions which are not fatal. Shortness of breath and

cough are the most common symptoms.

See Section 11 - Toxicological Information.

___________________________________________________________________________

4. FIRST AID INFORMATION

EYE CONTACT:

Immediately flush eyes with large amounts of water and continue flushing

until irritation subsides. If material is hot, treat for thermal burns and

seek immediate medical attention.

SKIN CONTACT:

Remove contaminated clothing. If material is hot, submerge injured area in

cold water. If victim is severely burned, remove to a hospital immediately.

INHALATION:

This material has a low vapor pressure and is not expected to present an

inhalation exposure at ambient conditions.

INGESTION:

May act as a laxative. Do not induce vomiting due to aspiration hazard.

If vomiting should occur, lower head below knees to avoid aspiration. Seek

immediate medical attention.

___________________________________________________________________________

5. FIRE AND EXPLOSION INFORMATION

FLAMMABLE PROPERTIES

Flash Point: >370 F (187.8 C)

Test Method: ASTM D-92 (COC)

Flammable Limits in Air

Upper Percent: No data available

Lower Percent: No data available

Autoignition Temperature: No data available

EXTINGUISHING MEDIA:

Use dry chemical, foam, or carbon dioxide.

FIRE FIGHTING MEASURES

SPECIAL FIRE FIGHTING PROCEDURES:

Water may be ineffective but can be used to cool containers exposed to heat

or flame. Caution should be exercised when using water or foam as frothing

may occur, especially if sprayed into containers of hot, burning liquid.

UNUSUAL FIRE AND EXPLOSION CONDITIONS:

Dense smoke may be generated while burning. Carbon monoxide, carbon

dioxide, and other oxides may be generated as products of combustion.

___________________________________________________________________________

6. ACCIDENTAL RELEASE MEASURES

PERSONNEL SAFEGUARDS:

Consult Health Effect Information in Section 3, Personal Protection

Information in Section 8, Fire and Explosion Information in Section 5, and

Stability and Reactivity Information in Section 10. Remove all sources of

ignition.

REGULATORY NOTIFICATIONS:

Notify appropriate authorities of spill.

CONTAINMENT AND CLEAN UP:

Contain spill immediately. Do not allow spill to enter sewers or

watercourses. Absorb with appropriate inert material such as sand, clay,

etc. Large spills may be picked up using vacuum pumps, shovels, buckets,

or other means and placed in drums or other suitable containers.

___________________________________________________________________________

7. HANDLING AND STORAGE INFORMATION

HANDLING:

Avoid breathing vapors or mist. Avoid contact with eyes. Avoid prolonged

or repeated contact with skin. Wash thoroughly after handling. Wash

clothing prior to reuse. May be slippery when spilled.

Fire extinguishers should be kept readily available. See NFPA 30 and OSHA

1910.106--Flammable and Combustible Liquids.

STORAGE:

Do not transfer to unmarked containers. Store in closed containers away

from heat, sparks, open flame, or oxidizing materials.

___________________________________________________________________________

8. EXPOSURE CONTROLS / PERSONAL PROTECTION INFORMATION

EXPOSURE LIMITS AND GUIDELINES

This product does not contain any components with OSHA or ACGIH exposure

limits. If oil mist is generated, exposure limits apply.

Oil Mist OSHA PEL: TWA 5 mg/m3

ACGIH TLV: TWA 5 mg/m3; STEL 10 mg/m3

PERSONAL PROTECTIVE EQUIPMENT

EYE/FACE PROTECTION:

Eye protection is not required under conditions of normal use. If material

is handled such that it could be splashed into eyes, wear plastic face

shield or splash-proof safety goggles.

SKIN PROTECTION:

No skin protection is required for single, short duration exposures. For

prolonged or repeated exposures, use impervious clothing (boots, gloves,

aprons, etc.) over parts of the body subject to exposure. If handling hot

material, use insulated protective clothing (boots, gloves, aprons, etc.).

RESPIRATORY PROTECTION:

Respiratory protection is not required under conditions of normal use. If

vapor or mist is generated when the material is heated or handled, use an

organic vapor respirator with a dust and mist filter. All respirators must

be NIOSH certified.

PERSONAL HYGIENE:

Consumption of food and beverage should be avoided in work areas where

hydrocarbons are present. Always wash hands and face with soap and water

before eating, drinking, or smoking.

ENGINEERING CONTROLS / WORK PRACTICES

VENTILATION:

If vapor or mist is generated when the material is heated or handled,

adequate ventilation in accordance with good engineering practice must be

provided to maintain concentrations below the specified exposure or

flammable limits.

___________________________________________________________________________

9. PHYSICAL AND CHEMICAL PROPERTIES

Appearance: Transparent, water-white liquid

Odor: Odorless

Vapor Pressure: <1 mm Hg @ 68 F

Vapor Density (air=1): >1

Evaporation Rate (EE=1): <1

pH: No data available

Percent Volatile by Volume: Nil

Boiling Point: 590 F (310 C)(approximate)

Volatile Organic Content: No data available

Melting Point: Not applicable

Molecular Weight: No data available

Specific Gravity: 0.86-0.88 @ 60/60 F

Average Carbon Number: No data available

Pour Point: No data available

Viscosity @ 100 F: No data available

Viscosity @ 40 C: No data available

Solubility: Insoluble in water; soluble in hydrocarbons

___________________________________________________________________________

10. STABILITY AND REACTIVITY INFORMATION

Chemical Stability: Stable.

Conditions to Avoid: Heat, sparks, flame.

Incompatible Materials to Avoid: May react with strong oxidizing agents.

Hazardous Decomposition Products: Carbon monoxide, carbon dioxide, and

other oxides may be generated as products of combustion.

Hazardous Polymerization: Will not occur.

___________________________________________________________________________

11. TOXICOLOGICAL INFORMATION

CARCINOGENICITY:

The International Agency for Research on Cancer (IARC) has concluded that

highly refined mineral oils are Group 3 substances, "Not Classifiable as

to their carcinogenicity to humans," based on inadequate human and

inadequate animal evidence. IARC has also concluded that there is no

evidence for the carcinogenicity to experimental animals of white oils

when administered by routes other than by intraperitoneal injection.

This product is not carcinogenic according to the OSHA Hazard Communication

Standard.

___________________________________________________________________________

12. ECOLOGICAL INFORMATION

No information available

___________________________________________________________________________

13. DISPOSAL INFORMATION

REGULATORY INFORMATION:

All disposals must comply with federal, state, and local regulations. The

material, if spilled or discarded, may be a regulated waste. Refer to

state and local regulations. Caution! If regulated solvents are used to

clean up spilled material, the resulting waste mixture may be regulated.

Department of Transportation (DOT) regulations may apply for transporting

this material when spilled.

WASTE DISPOSAL METHODS:

Waste material may be landfilled or incinerated at an approved facility.

Materials should be recycled if possible.

___________________________________________________________________________

14. TRANSPORTATION INFORMATION

U.S. DEPARTMENT OF TRANSPORTATION (DOT)

Highway / Rail (Bulk): Not Regulated

Highway / Rail (Non-Bulk): Not Regulated

The DOT description is provided to assist in the proper shipping

classification of this product and may not be suitable for all shipping

descriptions.

INTERNATIONAL INFORMATION

Vessel (IMDG): Not Regulated

Air (ICAO): Not Regulated

___________________________________________________________________________

15. REGULATORY INFORMATION

INVENTORIES:

AUSTRALIAN (AICS): Listed.

CANADIAN (DSL): Listed.

CHINESE: Listed.

EUROPEAN EC/EINECS: Listed.

JAPANESE ENCS: Listed.

KOREAN (KCL): Listed.

PHILIPPINE (PICCS): Listed.

U.S. (TSCA): Listed.

U.S. SARA SECTION 313:

This product is not known to contain any SARA, Title III, Section 313

Reportable Chemicals at or greater than 1.0% (0.1% for carcinogens).

U.S. SARA 311 / 312 CATEGORIES

Acute:

Chronic:

Fire:

Pressure:

Reactive:

Not Regulated: X

CANADIAN WHMIS CLASSIFICATION:

Not a Controlled Product under WHMIS.

___________________________________________________________________________

16. OTHER INFORMATION

Additional Information: None available.

Prepared By:

MSDS Coordinator

Conoco Inc.

PO Box 2197

Houston, TX 77252

The data in this Material Safety Data Sheet relates only to the

specific material designated herein and does not relate to use in

combination with any other material or in any process.

# indicates revised section.

End of MSDS