SECTION 1 – PRODUCT IDENTIFICATION

MANUFACTURER: PTI PROCESS CHEMICALS PHONE : (815)-759-3991 FAX: (815)-759-3996 PROD #: 695

ADDRESS: 4004 Dayton St. McHenry, Il 60050 EMERGENCY PHONE: INFOTRAC 1-800-535-5053

TRADE NAME AQUA AMMONIA PRODUCT TYPE: (AMMONIA HYDROXIDE SOLUTION)

SECTION 2 – INGREDIENTS

CHEMICAL NAME/COMMON NAME CAS NO. PERCENT(OPTIONAL) TLV(SOURCE)

AMMONIUM HYDROXIDE 1336-21-6 4

WATER 7732-18-5 96

SECTION 3 - PHYSICAL DATA

BOILING POINT (F) : 27- DEG C / 80 DEG F SPECIFIC GRAVITY (H2O=1.0): .9825 DEGREE BAUME: 12.35

VAPOR PRESSURE (mm Hg) : 590 @ 100 DEG F VAPOR DENSITY: .59 @ 32 DEG F

APPEARANCE: COLORLESS ODOR: PUNGENT

SOLUBILITY IN WATER: NEGLIGIBLE

_x_COMPLETE ____INSOLUBLE ____EMULSIFIABLE ____SLIGHT

EVAPORATION RATE(vsH2O) N/A

___FASTER ____SLOWER _____ ABOUT THE SAME APPEARANCE : CLEAR LIQUID

SECTION 4 – FIRE AND EXPLOSION HAZARD DATA

FLASH POINT (T.C.C.) : NONE. FLAMMABLE LIMITS : N/A

EXTINGUISHING MEDIA: WATER, DRY CHEMICAL, OR CO2

EXPLOSION : NOT CONSIDERED AN EXPLOSION HAZARD FIRE: NOT CONSIDERED TO BE A FIRE HAZARD

SPECIAL INFORMATION: FULL PRORECTI CLOTHING AND SELF CONTAINED BREATHING APPARATUS NIOSH APPROVED

SECTION 5 – REACTIVITY DATA

STABILITY : STABLE UNDER ORDINARY CONITIONS OF USE AND STORAGE

HAZARDOUS DECOMPOSITION PRODUCTS: MIXING WITH HOUSEHOLD BLEACH WILL CAUSE A DANGEROUS PRODUCTION OF CHLORINE GAS AND OXYGEN.

HAZARDOUS POLYMERIZATION: THIS SUBSTANCE DOES NOT POLYMERIZE.

INCOMPATIBILITIES (CONDITIONS TO AVOID) : REACTS VIGOROUSLY WITH BLEACH

(MATERIALS TO AVOID) : SLIVER, MERCURY, COPPER, ZINC

SECTION 6 – HEALTH HAZARD DATA

OSHA PERMISSIBLE EXPOSURE LIMIT: TLV 50 PPM

CARCINOGEN - NTP PROGRAM: N/A

ACGIH THRESHOLD LIMIT VALUE : N/A

CARCINOGEN - IARC PROGRAM: N/A

SYSTOMS OF EXPOSURE: GENERAL DISCOMFORT & EYE TEARING; NO LASTING EFFECT ON SHORT EXPOSURE. 400-700 PPM

Page 2

MATERIAL SAFETY DATA SHEETS

(CONTINUED) PRODUCT : AQUA AMMONIA

SECTION 7 – EMERGENCY AND FIRST AID PROCEDURES

EYES: FLUSH HOLDING EYELIDS OPEN WITH WATER FOR AT LEAST 15 MINUTES A 5% BORIC ACID SOLUTION MAT BE USED IN PLACE OF WATER. IMMEDATE RESPONSE IS ESSENTIAL. CALL A PHYSICIAN IMMEDIATELY.

SKIN: WASH AFFECTED AREAS WITH LARGE AMOUNTS OF WATER WHILE REMOVING CONTAMINATED CLOTHING. DO NOT ALPPLY SALVES OR OINTMENT OR COVER BURNS WITH DRESSING. INJURED AREAS SHOULD BE COVERED WITH CLEAN CLOTH PRIOR TO MEDICAL CARE. DO NOT ATTEMPT TO NEUTRALIZE THE AMMONIUM HYDRXIDE. CALL A PHYSICIAN.

INGESTION: DRINK LARGE AMOUNTS OF WATER FOLLOWED BY NEUTRALZING AGENTS SUCH AS DILUTE VINEGAR, LEMON JUICE, ORANGE JUICE, GRAPEFRUIT JUICE OR LIME JUICE. INDUCE VOMITING. CALL A PHYSICIAN IMMEDIATELY.

INHALATION: MOVE EXPOSED PERSON TO FRESH AIR, IF NOT BREATHING PERFORM ARTIFICIAL RESPIRATION, KEEP WARM, GET MEDICAL HELP IMMEDIATELY ADVISE PHYSICIAN NOT TO USE ADRENALIN.

SECTION 8 – SPECIAL PROTECTION INFORMATION

RESPIRATORY PROTECTION: USE A FULL FACE PIECE RESPIRATOR

VENTILATION REQUIREMENTS: MAXIMUM VENTILATION EYE PROTECTION: APPROATE EYE AND FACE PROTECTION REQUIRED

PROTECTIVE GLOVES: NOEPRENE, VITON, PVA OR PVC COATED GLOVES

OTHER PROTECTIVE CLOTHING: APRONS AND OTHER PROTECTIVE CLOTHING

EYE WASH STATION SHOULD BE AVAILABLE IN WORK AREA.

SECTION 9 - SPILL OR LEAK PROCEDURES

SPILL RESPONCE : CONTAIN SPILL TO MINIMIZE AMMONIA VAPORIZATION.

WASTE DISPOSAL METHODS: DILUTE WITH WATER AND FLUSH TO LOCAL SEWER SYSTEM, IF PERMITTED. SOLID WASTE MUST BE DISPOSED OF IN A PEMITTED WASTE MANAGEMENT FACILITY. ENSURE COMPLIANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.

SECTION 10 - STORAGE AND HANDLING INFORMATION

STORE IN COOL, DRY, VENTILATED AREA. PROTECT AGAINST PHYSICAL DAMAGE. KEEP SEPARATE FROM INCOMPATIBLES. KEEP OUT OF REACH OF CHILDREN

* NOTICE

THE INFORMATION GIVIN HEREIN IS PROVIDED IN GOOD FAITH AND IS BELIVED TO BE CORRECT AS OF THE DATE HEREOF. HOWEVER, PTI PROCESS CHEMICALS MAKES NO REPRESENTATION AS TO THE COMPREHENSIVNESS OR ACCURACY OF THE INFORMATION. IT IS EXPECTED THAT THE INDIVIUALS RECEIVING THE INFORMATION WILL EXERCISE THEIR INDEPENDENT JUDGEMENT IN DETERNINING ITS APPROPRIATENESS FOR A PARTICULAR PURPOSE. ACCORDINGLY PTI PROCESS CHEMICALS WILL NOT BE RESPONSIBLE FOR DAMAGES OF ANY KIND RESULTING FROM THE USE OF OR RELIANCE UPON SUCH INFORMATION. NO REPRESENTATIONS, OR WARRANTIES, EITHER EXPRESS OR IMPLIED, OF MERCHANTABILITY, FITNESS FOR PARTICULAR PURPOSE OR OF ANY OTHER NATURE ARE MADE HEREUNDER WITH RESPECT TO THE INFORMATION SET FORTH HEREIN OR TO THE PRODUCT TO WHICH THE INFORMATION REFERS.